1996 Mitsubishi Eclipse — 11 Open Recalls & Full Specs

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Campaign: 00V421001 · Filed: 18/12/2000

Defect description: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective action: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign: 98V069001 · Filed: 26/03/1998

Defect description: VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.

Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Corrective action: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.

FUEL SYSTEM, GASOLINE

Campaign: 96V158001 · Filed: 27/08/1996

Defect description: THE FUEL TANK GASKETS FOR THE FUEL PUMP AND/OR GAUGE UNIT GASKET COULD HAVE BEEN INCORRECTLY INSTALLED ALLOWING FUEL OR FUMES TO ESCAPE.

Consequence: IF AN IGNITION SOURCE WERE PRESENT, THE FUEL LEAKAGE COULD RESULT IN A FIRE.

Corrective action: DEALERS WILL INSPECT THE FUEL TANK AND IF THE GASKETS ARE FOUND TO BE LEAKING, REPLACE THE FUEL TANK, CAPS AND GASKETS.

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Campaign: 99V066001 · Filed: 05/04/1999

Defect description: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Corrective action: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

EXTERIOR LIGHTING

Campaign: 06E060000 · Filed: 29/06/2006

Defect description: CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Corrective action: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

POWER TRAIN — 12/27/2010

TL*THE CONTACT OWNS A 1996 MITSUBISHI ECLIPSE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSFER CASE SUDDENLY STALLED AND LOCKED ALL FOUR WHEELS; HE WAS UNABLE TO GET THE VEHICLE TO MOVE. THE VEHICLE WAS TOWED TO A DEALER WHO INFORMED THE CONTACT THAT HE NEEDED TO REPLACE TRANSFER CASE AND THAT THEY COULD NOT ASSIST WITH REPAIR EXPENSES AS THE VEHICLE WAS NOT INCLUDED IN RECALL 98V069001 (POWER TRAIN: AUTOMATIC TRANSMISSION). THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE

POWER TRAIN — 12/22/2007

I WAS GOING ABOUT 65 MILES PER HOUR ON THE FREEWAY, WHEN THE TRANSMISSION STARTED TO MAKE A LOUD REVVING NOISE AND BEGAN TO DOWN SHIFT AT AN ACCELERATED RATE. THE ECLIPSE NOW HAS A SHIFTING PROBLEM TO WHERE THE CAR DOES NOT HAVE THE DRIVE TO MOVE FORWARDS NOR BACKWARDS. I WAS TOLD BY A TRANSMISSION SPECIALIST AND CLOSE FRIEND, THAT ALL MY GEARS WERE ALL WIPED OUT ALL AT THE SAME TIME AND THAT THE THROTTLE CABLE WAS EITHER LOOSE OR BROKEN. HE ALSO MENTIONED THAT HE FOUND IN THE TRANSFER CASE, OF

POWER TRAIN,ELECTRICAL SYSTEM — 12/21/1998

CLUTCH LINE HAS BLOWN, CAUSING THE VEHICLE TO COMPLETELY SHUT DOWN. DEALER REPLACED THE SHORT BLOCK WHICH ONLY TEMPORARILY REMEDIED THE PROBLEM. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.